Flushing the system with the engine running is a 3 or 4 man circus. Putting the wrong fluid in will swell the steering rack seals and cause them to leak, i found out the hard way on my B5, had to replace the steering rack, luckily i did it myself saving £400 although exchange rack was £200. Always wear gloves and wear safety goggles when handling Audi fluids. One to operate the key and steering wheel, one to hold hoses and the container, one to pour, and another to point and laugh at all the fluid going everywhere. The writing on the reservoir also says it should be mineral oil, the comma stuff i got today is synthetic. Its gonna be a pain flushing the power steering but it must be done.
Did that on my 'benz, and from now on I'll just lift it up and turn the wheel. Prices, specifications, manufacturers, availability, and special offers are subject to change without notice. Do not rev the engine up. We have worked hard to design a site that caters to everyones Audi A4 Power Steering Fluid needs. Is your A4 Quattro hard to turn? The mounting location of the steering pump differs depending on model and engine configuration and may be This variable may mounted near other heat generating components i.
It does look like Pepsi in the picture doesn't it? Changing your Audi power steering fluid prevents failure of expensive steering pumps, rack and pinions, and other steering related parts. The old oil in the system is brown, i dont know if someone has used the wrong stuff or is the green stuff has gone dirty. Entering your vehicle information in our Year Make Model selector up top, helps ensure you get an auto part that fits your car, truck or other type of vehicle. Do not rev the engine up. It means a lot to me! They apply pressure to the reservoir filter insert. In a few days, check the power steering fluid level in your A4 Quattro to make sure you don't have a leak.
Today's power steering fluid must facilitate proper steering pump operation, withstand high temperatures, and ensure reliably over a long period of time and under all vehicle operating conditions. No problems with our own vehicles and no problems with our customers vehicles. I have used this to fill the power steering fluid level, as i need to get my car going, ill get the green mineral stuff from audi asap and flush the old oli and the comma oil out. There should be two plastic retaining clips which… hope this helps i have a 97 and replaced the water pump all i had to do was remove the alternator and loosen the power steering bracket and the water pump slides out from between the engine and bracket. Get the right size socket and start unscrewing until the whole casing comes off. This information will typically be located in the back of the manual in a section title fluid capacities and specifications.
And original fluid was to above mentioned spec. There're two got same name, same spec, but different shape. The old oil in the system is brown, i dont know if someone has used the wrong stuff or is the green stuff has gone dirty. Turn the steering wheel full lock about 10 times from side to side. If you don't see it, it's gone, the wire or connector is quite easy corroded.
Another can see through from front bumper lower section, in front of air conditioner condenser, on the bracket of power steering cooler. An Audi power steering pump is just one component of concern. Back then, a double vain hydraulic pump performed these two functions power assist braking and power assist steering , requiring an advanced hydraulic oil that could properly function under the inherent high operating pressures and temperatures generated within this system. The writing on the reservoir also says it should be mineral oil, the comma stuff i got today is synthetic. We feel this isn't logical.
Before adding power steering fluid, be sure to check your owners manual to determine what type of power steering fluid to add to your A4 Quattro. Interesting thing is it's leaking less now : Note: this is not recommendation, just sharing my own experience interesting stuff, seems like the right fluid is needed though or you can end up with leaks. Experience has shown that changing your fluids is the single most important preventive maintenance routine you can perform to avoid vehicle breakdowns. It has to do with viscosity I got this info from a certified Audi tech. We love when auto parts experts come to our site and we love when car parts newbies come to our site.
Loosen the clamp and remove the hose then drain the Audi power steering fluid. Is your A4 Quattro hard to turn? Yet, for many Audi owners, this seems to be one of the most neglected areas of maintenance. Find the rubber hose that attaches to the tubing located near the drivers side lower corner of the radiator. Stick your index finger into the reservoir and pull out the filter insert and clean or replace it. This is how I changed mine: You need a socket set and a screw driver. Replace worn tie rods and ends to keep your steering taut, responsive, and safe. Turn the steering wheel full lock side to side about 10 times.
It is not intended to replace the factory manual. Adding power steering fluid to your A4 Quattro is easy and should be done whenever your power steering fluid is low. It is not intended to replace the factory manual. Open the boot and in line with the light there should be a round indent in the carpet. Adding power steering fluid to your A4 Quattro is easy and should be done whenever your power steering fluid is low. Overview Of How To Change Audi Power Steering Fluid For: 1984-1991 Audi 5000, 100, 200, V8 Models 1984-1991 1990-1991 Audi 90 20 Valve Models 1990-1991, 1992-1996 Audi S4, S6 Models Refer to the factory manual for Audi hydraulic system instructions.