I've been using this technique for 14 years with excellent results. Check out our complete line of products. . Check for leaks and fluid level before you take it for a ride. This article applies to the Ford Super Duty 2004-2014 If. Are you a weekend warrior, or love a good day off-roading? Check your transmission fluid's color against this chart.
Its about 3 feet long. Clean transmission oil pan surface with rag and cleaning solvent this pan can be reused. Install the new gasket on the pan and use a few bolts in the corners to hold it in place. I could not find this information in my other service manuals for my other vehicles. You should see the white cap of the transmission filler. It will void your warranty if you use anything else. The transmission fluid dipstick is circled in red.
Lift the vehicle off ground with a jack, and support with jack stands on all four sides of the vehicle. It's pretty well hidden and you may need a flashlight to locate it. If the truck has recently been in use, the engine will be warm and could possibly cause a minor burn. Tranny fluid requirements are on the end of the dipstick. When doing so, work around pan, tightening each bolt a little at a time until specifications are reached.
Remove torque-converter cover with ratchet and socket, and allow fluid to drain. Adhering to the suggested maintenance will ensure the vehicle's transmission will continue to work properly, and will assist in preventing future damage. Your dipstick will have both cold and hot level indicators. Servicing the transmission in a Ford F-350 consists of changing the fluid as well as the filters specified by the manufacturer's maintenance schedule. Also, you should check the level with the engine running and temp above 50 degrees. Due to the heat generated in the transmission, the fluid can break down over time. Dirty fluid can cause issues ranging from a check engine light to damaged transmission internals.
Remove it and replace it with the new one. Have you tried to shift your Super Duty into gear but it just won't budge? Learn how to change out your old, bad fluid for the new, good stuff. This won't replace all the fluid that way, but by doing it more often than the recommended maximum service interval will keep your fluid fresher than the recommended fancy full change long interval method. I will check my stick also. For years I attempted to purchase an aftermarket service manual for this vehicle and could not find. If it is dark red, brown or black, you need a fluid and filter change. Look at both the color and the consistency of the fluid.
Bolt the pan in place and add 5 quarts on trans fluid and your ready. You can check when it's cold, but transmission fluid will expand with heat, making the warmer reading a more accurate one. Step 2 - Check your transmission fluid level A warm engine check is essential to determine the quality of your transmission fluid. It should be either bright red, or in some cases, nearly clear. Late model F-150's with the 6R80 have a short dipstick accessible on the transmission. There you are, charging up an on-ramp in your F-150 or F-250 Super Duty when your transmission suddenly decides to transmit your engine's power into violent shaking. Allow the front bolts to drop slightly to let fluid drain.
Is your truck telling you the transmission has overheated? Your 350 dipstick should be in the same position as the 150. Dana rear axles also contain a synthetic lubricant but do required a change. You'll want to test the fluid while it's warm if your truck is in driveable condition. Install new transmission oil pan gasket. Mark, doesn't the 5r110 need to be flushed using a hot flush machine, because of there being a thermastat type bypass in it? Is your Super Duty suddenly and stubbornly refusing to go into reverse? Some applications may vary based on cooler size and if equipped with an in-tank cooler. I don't know the proper name for this bypass. Differential Gear Oil F350 Super Duty Rear,Dana 80 8.
Ensure the filter seals come off of transmission. I have a 1989 e-150 van- 4. If pan does not come off freely, carefully pry on corners with a standard screwdriver. Always change your transmission fluid right while the engine is hot and right after you have shifted the lever thru all the positions. Step 1 - Locate the transmission dipstick Always use caution when opening and securing the hood of your truck. If not, check out our step by step guide on how to diagnose and. Pro Tip Before you decide to fill up on transmission fluid, make sure you're checking while the transmission is up to temperature.