Although rollovers are comparatively rare events, the consequences are quite serious and Saab has installed an active protection system in the new 9-3 Convertible. This could cause personal injury and damage the soft top mecha- nism. The engine should be at normal operating temperature. The light switches are located in the roof con- sole. To ensure that the soft top cover is fully closed, there is a position sensor located on each of the two hinges 5. The second 4 , third 5 , fourth 7 and fifth 8 bows are made of steel and mounted on a linkage, one on each side, from which they are controlled mechanically.
Place the attaching plate together with the hydraulic lines in mounting position. Refer also to the terms and conditions of the Performa- tion Limited Warranty described in the war- ranty booklet. On the ends of the inner frame are linkages joined to the soft top mechanism. Maximum Loaded Vehicle Weight: The sum of curb weight; accessory weight; vehi- cle capacity weight;and production options weight. Unlocking the trunk lid manually 9-3 Convertible. These hooks are controlled by a hydraulic cylinder 13 on the first bow 1. Note that national restrictions may apply to trailer speeds and weights see page 178.
I'm assuming that's what it is unless a hydraulic line has a leak. Remove the cable tie and open the hydraulic line attachments. The inflatable curtains inflate at the same time as the side airbags in the front seats in case of a side-on impact. Key to its enhanced abilities is a rigid body structure - almost three times stiffer than that of its predecessor - and an all-new suspension layout. The outer frame 4 is glued to the outer roof 2 and headlining 3. Soft top storage drive device The soft top storage drive 1 is operated by a cable 2 via an idler pulley 3 from the sixth bow hydraulic cylinder. Now with renewed confidence, this is what I did: 1.
Automatic closing certain variants only Slide the control forward to its second posi- tion and release it. Close the soft top completely. Your Saab dealer will be pleased to advise you on the best tires for your car. The headlining is also fastened to the first bow on the right and left- hand sides with plastic clips. If you choose the single zone setting, the entire cabin is treated as one zone. Clearance for soft top operation: height, min. The mirror glass can also be adjusted man- ually by gently pressing the glass in the desired direction.
If I could just raise the tonneau and keep it open this would make access to the area easy. Be sure the electrolyte in the battery is not frozen. Lock hooks The soft top mechanism comprises two parallel metal rails running along the sides of the soft top. No manual handling is necessary. Step 5, locking the soft top cover The first bow is secured and the soft top cover is closed and locked. This is particularly important if the car has been through an automatic car wash, as these sometimes leave a wax coating on the wind- shield.
In addition, the entries through the attaching plate are marked to avoid confusion. Important Hydraulic lines must be refitted as they were earlier or there will be a risk of them being damaged when the soft top is operated. Adjust the rake angle of the backrest with the rear lever. The guide straps 10, 11 control the fourth 7 and fifth 8 bows while the soft top is being operated and also secure the soft top when it is raised. The soft top, which is pulled taut on the mechanism, comprises three layers, one outer water- repellent, one insulating and one interior. The label tells you the proper size, and recommended inflation pressures the the tires on your vehicle. If so, have the system checked at a Saab dealer.
The air is evacuated via openings in the parcel shelf. If poor wiper performance is experienced, clean the windshield with washer fluid. In Canada, please call the Saab Customer Assistance Centre at 1-800-263-1999. When the ignition is turned off, the pump will stop and the valves will return to their positions of rest. One front rail that is integrated with the first bow 1 , a centre rail 2 and a rear rail 3. The needle should be in the middle of the scale when the engine is at normal operating temperature. Glove compartment lighting certain variants only 1 Remove the lamp housing using a short screwdriver.
Don't waste time calling around to your local bookstores or waiting for a repair manual to arrive by mail. Classifieds are to be listed in pages. Trunk lighting The trunk lighting is switched on and off when the trunk lid is opened and closed. The engine can be started. The system is operated with a switch on the instrument panel or a remote control.